kohler

Craftsman T2400 Kohler engine (24 hrs on the guage) purchased from Lowes May 2022. It has been doing great. Wife can never remember to choke before cranking OR to take it off choke once it is cranked. Yesterday she jumped on the tractor, cranked it up and took off with the choke engaged. I...

Have a 2016 Dixie Chopper Classic with a Kohler ECV870-3013 and it has an odd issue. It starts fine and runs good for about 2-3 minutes then gets weak RPM drops from 3300 to 26-2800 and exhaust smells rich. Shut it off, restart it and runs good for 2-3 minutes rinse repeat. Check the primary...

Can't figure out why this carb is leaking. It's my newest one so everything looks new but it leaks from the front out of the main jet. The little rubber stopper valve is a soft rubber I think works against me blowing into it. Any ideas?

The short video attached should explain it better than I can. Essentially I'm not getting 12v to my fuel shutoff solenoid unless I unplug the 12 volt lead to my DSAM. One thing to note in addition to what I mentioned in the video about unplugging the other leads to see if anything changed...

Kohler on Grasshopper 225V,2018, we bought this mower used at an estate sale about a year ago with less than 700 hours and were told it had just been serviced! I put about 200 hours on it and decided to change oil and filter, used all Kohler parts machine ran great for about 4 hours, yesterday...

I goofed while I was tinkering with the engine control and took off the springs without a picture, rookie move, I know. I can't seem to find a picture of video anywhere on the internet that would give me some direction. I see diagrams online but they aren't helpful. Does anyone have a picture...

Bought a craftsman dgs6500 with a kohler sv735 vtwin engine for $300. Previous owner replaced the head gaskets and couldn't get it started or something? This was a few months ago before all the snow here in oregon. Got it running...BARELY. Was smoking bad when running (Major disappointment #1)...

Cub XT1 LT46 Mfg 08/22/2018 Model KT725-3078 After running for a short time (5-10 minutes) engine bogs down and dies. Doesn't matter if it is under load or not. I have found I can get it to re-start by spraying some carb cleaner followed by starting fluid directly into the carb but it dies...

Hello all, I'm working on an old (2009) Bad Boy Pro 27 with a Kohler 27 hp. I did a longblock swap using a used longblock and the original accessories including charging system etc. Mower preformed perfectly for several hours then began blowing the main fuse. I traced the issue back to the...

I am doing a tune up on the 2011 Troy Bilt riding mower/tractor. It dues not appear to have an impulse fuel pump or at least I have not found it. One was sent in my parts kit. Should I go ahead and install? Excuse my ignorance but the smallest tractor I have is a Ford 4610SU with 56...

Hi, I'd appreciate any suggestions you might have for the following problem. About 15 minutes into the first cut of this spring, my mom's Husqvarna lawn tractor with KT725 engine suddenly started "cycling" like somebody was pushing the throttle back and forth about once per second (see video...

Battery pushing 12.56amps. With the meter I see 12.56 also at the first post of the solenoid with no key in ignition. I have continuity throughout. Installed new solenoid, new ignition switch. Still getting nothing. No click. Double-checked the ground on the solenoid. 4 post solenoid. Two small...

Has anybody put the Command Twin solenoid shift starter on a Courage twin in place of the inertial drive starter. BIL Cub Cadet snapped the starter shaft while trying to start the mower for an oil change the other day. Was thinking about doing the upgrade if it will fit.

I've had this mower since new. Great machine. Only problem was the "Smart" choke. Plastic broke off of it. I put choke cable. Works great. I have a problem now that when I turn the key sometimes it just turns the flywheel 1/4 or 1/2 turn and stops and sometimes it starts. So far it's started...

i have a hustler raptor with a kohler 7000 series engine..in my air filter housing i can smell gas..the filter looks like gas has got on it too..im trying to determine if this is a carb problem which i am thinking it is or something else..the mower runs fine and does not smoke..any help will be...

Well I needed a mower in a hurry and ended up with this well-used Scotts rider. Question 1 Can't find an owners manual anywhere! My research indicates this mower was made by Murray. Is that correct? If so I wonder if there is Murray wth the same specs as the Scotts mower. If I can't find a...

Was mowing lot next door and suddenly the motor just starts racing. I shut it down and it took a while to shut off. I started back up but the motor is still racing at top speed pretty much no matter what position throttle cable is in. Throttle cable seems to be operating properly. It's...

Morning, I'm close to having this machine all back together but I cannot figure out what is missing with the throttle adjustment. I can choke it to start manually as well as use the throttle cable but when I adjust the throttle the engine does not go to idle or rev up accordingly. Any help is...

Kohler XT6.75 PN: PH-XT675-2044 SN:4334903388 HUAYI Corp Carb # 1405368 I've been searching for a Carb kit for this engine and none available. All I require is the 2 o-rings that are on the Pilot jet. Does one of you wizards know the size of these o-rings or could I purchase o-rings for...

I believe it's a 2018 if it matters. From zero throttle to half throttle the engine is at idle at about 1600 RPMs. From half throttle to Full Throttle the RPMs increase to about 2600 Rpms (sitting still, pto not engaged). What should I be expecting on this mower? I feel like the throttle lever /...

My brother in law has a Scag Liberty Z with a Kohler KT725 engine and it won't start sometimes. Battery is fine, checked all safety switches and seat and brake switches and they're testing ok but the engine won't try to start with the key ignition. You can hear the fuel Solenoid click when you...

No spark on cyl 1. Have power to coil and continuity from pin 22 on the ECU connector to coil connection/trigger wire. ECU is bad? And it's discontinued. Spark was intermittent before it finally died.

My old Kubota with the 15 hp Kohler became almost impossible to start. For a year we struggled with getting it to fire strong enough to overcome the compression release. Once running it was powerful and ran normally. Then, getting it ready for this summer's mowing I could not get it to start...