Results 1 to 8 of 8
  1. #1

    Join Date
    May 2012
    Posts
    2
    Location
    Louisiana
    Mower
    Bob-Cat

    Carburetor problem? 25 hp Kawasaki

    I have a 2001 25 hp Kawasaki engine on a bobcat mower. It runs great when the blades are not engauged but when i engauge the blades it runs great for 30 minutes then it dies. It restarts and I run it for a few second then dies. It just keeps dieing, it seems to me like it's not getting fuel...I check the tank cap it's open, the fuel filter is new, I check the fuel pump and it's has a good stream . The only thing I can figure its the carburetor. Ive even tried seafoam and nothing it still does it. Any suggestion ?
    Last edited by HBA; 05-17-2012 at 10:56 PM.

  2.  

  3. #2
    Edwards saw service's Avatar
    Join Date
    Jul 2011
    Posts
    74
    Location
    Pennsylvania
    Mower
    John Deere

    We have this problem come into the shop with older bob cats. How many hours are on the unit? It may be time for the heads to be replaced or the valves to be lapped.

    Edwards Saw Service in Glen Mills PA

  4. #3

    Join Date
    May 2012
    Posts
    2
    Location
    Louisiana
    Mower
    Bob-Cat

    Re: Carburetor problem? 25 hp Kawasaki

    The mower has over 2000 hours but the engine has less than 200 hour.

  5. #4

    Join Date
    Apr 2012
    Posts
    548
    Location
    Texas
    Mower
    Troy-Bilt Super Bronco

    Re: Carburetor problem? 25 hp Kawasaki

    I'm sure you already know this but an engine needs the right amount of air, the right amount of fuel, compression and spark at the right time to operate properly. If one of the above factors are missing or in the wrong proportion the engine will not run or may run poorly. When the symptom is present find out which one(s) is/are missing from the equation.

  6. #5

    Join Date
    Jun 2011
    Posts
    428
    Location
    Knoxville, TN
    Mower
    Eager

    Re: Carburetor problem? 25 hp Kawasaki

    It doesn't take much to get an engine to run erratically. One would think that less than 30 minutes would be enough to cause an intake valve with insufficient gap to heat up enough to come off its seat. Wouldn't hurt to go through the carburetor and give a good cleaning with carburetor cleaner and re-assemble. Enrichen the mixture screw some couldn't hurt. Too much and it would blow black smoke~~~ I'd take the valve cover off and look at the gaps and see what they are set at.

  7. #6

    Join Date
    May 2014
    Posts
    1
    Location
    New York
    Mower
    Snapper

    Re: Carburetor problem? 25 hp Kawasaki

    Quote Originally Posted by HBA View Post
    I have a 2001 25 hp Kawasaki engine on a bobcat mower. It runs great when the blades are not engauged but when i engauge the blades it runs great for 30 minutes then it dies. It restarts and I run it for a few second then dies. It just keeps dieing, it seems to me like it's not getting fuel...I check the tank cap it's open, the fuel filter is new, I check the fuel pump and it's has a good stream . The only thing I can figure its the carburetor. Ive even tried seafoam and nothing it still does it. Any suggestion ?
    i had the exact same problem with my 25hp kowasaki. i would mow for half an hour fine then it would quit. it would restart with the choke pulled half way out but run rough. local mecanics were convinced it was a fuel problem. after cleaning the carb, eliminating ethenol, changing plugs, replacing fuel filter and pump, turns out the problem was an ignition coil. it would break down when it got hot. i replaced both at a cost of $95 and a couple hours. hope this saves you the agrivation i went though.

  8. #7
    FloGro's Avatar
    Join Date
    Apr 2014
    Posts
    32
    Location
    Florida
    Mower
    Honda

    I would definitely check to see if it has spark after it gets nice and hot and shuts off, it sounds like a classic ign coil problem because it runs so long before shutting off, if it were fuel related it would shut off alot sooner. Fuel cap venting properly is something to consider too

  9. #8

    Join Date
    Nov 2012
    Posts
    169
    Location
    New York
    Mower
    Ferris

    Re: Carburetor problem? 25 hp Kawasaki

    Quote Originally Posted by FloGro View Post
    I would definitely check to see if it has spark after it gets nice and hot and shuts off, it sounds like a classic ign coil problem because it runs so long before shutting off, if it were fuel related it would shut off alot sooner. Fuel cap venting properly is something to consider too
    I think he said the cap was ok. I agree with the bad coil and it's an easy thing to check. gregjo1948

Similar Threads

  1. Kawasaki Carb
    By JDMATT in forum Kawasaki Engine Forum
    Replies: 2
    Last Post: 04-03-2012, 12:55 AM
  2. Tire Pressure on 2001 33" RER?
    By gitnby in forum Snapper Forum
    Replies: 2
    Last Post: 10-10-2011, 11:44 PM
  3. 2001 Kubota G1800 For Sale
    By Kubota_Diesel in forum Kubota Forum
    Replies: 1
    Last Post: 09-08-2011, 09:19 AM
  4. Kawasaki FB460V
    By jakesmurray in forum Kawasaki Engine Forum
    Replies: 0
    Last Post: 09-02-2011, 12:19 AM
  5. Kawasaki or Kohler????
    By coltscardinalsfan in forum Mower & Equipment Buying & Pricing
    Replies: 18
    Last Post: 08-23-2011, 02:50 PM

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •